河南福彩网

全国统一销售电话

18660760260

如电话无法接通,请您拨打集团 销售专员热线

锚机
船上用于收放锚及锚链的机械

锚机

锚机是起锚和抛锚的机械,同样也作为绞缆之用。按驱动形式可分为:手动、电动、液压。

产品介绍/Product introduction

锚机

主要用于船舶上抛 (起)锚作业,以达到固定船位;在系泊机动中,控制船的速度和船首的转动
等作用。它主要有原动机、减速装置、离合器、绞盘、链盘、刹车、操纵装置等组成。

Anchor machine is mainly used in the ship on (the) anchor operation, to achieve the fixed position; In the mooring motor,The
rotation of the bow and control the speed of the ship, and so on. It is mainly a prime mover, speed reducer,Clutch, winch
chain plate, brake, controls, etc.
锚机

锚设备和系泊设备是船舶重要的甲板设备,对保障船舶安全发挥着重要作用。锚设备是船舶控制船速,抛锚、起锚和协助靠离泊的主要甲板设备。

了解更多 锚机图片

锚机

是船上用于收放锚及锚链的机械。用人力、蒸汽机、电动机、液压马达等作为动力。通常安装在船的首楼甲板上。其发展趋势是用一台机组实现起锚、系泊、自动系泊和带缆等作业。按照驱动形式可以分为:手动、电动、液压。

产品组成:电动锚机采用耐磨船用锚链轮、船用硬齿面减速机、进口船用ABB电机、主令电气控制箱、主令控制器为IP56型及无石棉刹车带等组成。

锚机产品介绍 锚机产品介绍

产品分类/Product categories

MAOJI、JIAOLANJIYIQUDONGFANGSHIKEFENWEIDIANDONGQUDONG、YEYAQUDONGHEZHENGQIQUDONGSANZHONG。

Windlass and mooring winch to drive the way can be divided into electric drive, hydraulic drive and three kinds of steam drive.
锚机
01

电动驱动方式

Electric drive mode

河南福彩网DIANDONGQUDONGFANGSHISHIZHIYISANSUJIAOLIUDIANDONGJIZHIJIEQUDONGMAOJI、JIAOLANJI,JUYOUSHEBEIJIANDAN,SHENGCHANWEIHUCHENGBENDIDEYOUDIAN,DANZAISUDU、LALIXINGNENGFANGMIANBURUZHENGQI、YEYAQUDONGDEMAOJI、JIAOLANJI。TONGSHI,YOUYUDIANLIQUDONGXITONGCUNZAIMOUXIEGUYOUDEQUEDIAN,SUOYI,ZAIZHONGDAXINGYOULUNSHANGHENSHAOCAIYONG。

锚机
锚机
02

液压驱动方式

Hydraulic drive way

河南福彩网YEYAQUDONGFANGSHISHIYOUDIANDONGJIQUDONGYEYAYOUBENG,JIANLIDONGLIYOUYA,ZAIYOUYEYAMADALAIQUDONGMAOJI、JIAOLANJI。JUYOUDIAOSUXINGNENGPINGWEN,ERQIEKEYIWUJIDIAOSU,QIDONGLIJUDADENGTEDIAN。SUOYI,ZAIZHONGDAXINGCHUANBOBEIPUBIANCAIYONG。

锚机
锚机
03

蒸汽驱动方式

Steam drive mode

河南福彩网ZHENGQIQUDONGFANGSHISHIYOUZHENGQILAIQUDONGZHENGQIJI,ZAIYOUZHENGQIJILAIQUDONGMAOJI、JIAOLANJI。JUYOUJIEGOUJIANDAN、ANQUAN、JIANGUNAIYONG,YOUJIAOHAODESUDUHELALIXINGNENG。DANQIZHUANJUBUJUNYUN,ZAIDIZHUANSUSHIYOUQIMINGXIAN。ZHENGQIQUDONGMAOJI、JIAOLANJICENGZAIYOULUNSHANGBEIPUBIANCAIYONG,DANXIANZAIYIHENSHAOSHIYONG。

锚机

产品要求/Product requirements

MAOJIYOUWOSHIHELISHILIANGZHONG,SHANGCHUANSHANGYIBANCAIYONGWOSHIMAOJI。ERLISHIMAOJIYECHENGZUOQIMAOJIAOPAN,TADEDONGLIBUFENSHEZAIJIABANXIAMIAN,YIJIESHENGJIABANMIANJI,JUNJIANSHANGDUOCAIYONGLISHIMAOJI。JINLAIDEDAXINGCHUANBO,YINWEIMAOJICHICUNGUODA,CHUANSHOUJIABANNANYIRONGNA,QIEDUICAOZUOBULI,GUYEYOUCAIYONGLISHIMAOJIDE。

Windlass has horizontal and vertical two kinds, generally adopts horizontal windlass on merchant ships. And vertical anchor machine also called windlass, part of its power in below deck, to save the deck area, ships use vertical anchor machine more. Recent large ship, because the anchor machine size is too big, difficult to accommodate bow deck, and adverse to the operation, therefore also has the use of vertical anchor machine.
锚机要求
1

锚机

应有独立的原动力驱动。锚机安装
应保证锚链引出时三眼(锚链筒、制链
器、和链轮)成一线。
2

锚机

的额定拉力应不小于41.68d2N,当d小于25mm时
额定拉力应不小于36.8d2N,d为链径,单位为毫米。在
使用额定拉力时的绞锚平均速度应不小于9m/min。
3

锚机

在额定拉力和额定速度下,应能连
续工作30min,并应能在不小于1.5倍
额定拉力的过载拉力作用下连续工作
2min;此外锚机还应设有过载保护装
置,过载时能转到中速运转。
4

锚机

链轮上的刹车装置应工作可靠,能制动锚链断裂负荷45%的拉力;锚机的链轮与载荷轴之间应设有离合器;刹车与离合器应操纵方便可靠。
锚机要求 锚机要求

产品操作/Product operation

锚机操作

QIDONGQIANZHUNBEIGONGZUO

+

1、锚机启动之前,应检查各固定部位螺母、螺栓是否正常,检查并加足各转动摩擦部位的润滑油脂;
2、检查锚机的转动及传动部位有无障碍物,附近有碍起锚、绞缆操作的物品应清理移开;
3、退出离合器,使链轮与锚机的转动轴脱离开;
4、接通电源,启动电机,依次一档、二档作空车正反向运转试验,若空车运转正常,准备投入使用。

QIMAOCAOZUO

+

1、转动离合器的手轮,使锚机轴与锚链盘的离合器接合到位,并可靠固定;
2、脱开锚链制止器。松开锚链盘的刹车装置;
3、打开冲洗锚链水阀门;
4.启动锚机,用一档速度起锚,待锚爪出土,锚链呈垂吊状态时,方可逐渐增速二档起锚。当锚杆出水时,应即减为一档。
5、锚到位后,锚链盘刹紧制动,放下锚链制止器并插入插销固定;
6、离合器退出到位,锚机试空转;
7、关闭电源;关闭锚链冲洗阀,清除现场的泥污、杂物。

锚机操作
锚机

PAOMAOCAOZUO

+

1、脱开锚链制止器;
2、锚链盘与锚机轴离合器脱离到位并固定;
3、松开锚链盘刹车带,抛锚;
4、抛锚完毕,放下锚链制止器并插好销子;
5、刹紧刹车带制动锚链盘。

注意事项/Announcements

  • 01

    JIANCHACHILUNXIANGYOUWEISHIFOUZHENGCHANG;

    Check whether the gearbox oil level is normal;
  • 02

    JIANCHAGEYOUBEINEIRUNHUAZHISHIFOUBAOMAN;

    Check the oil cup grease inside is full;
  • 03

    河南福彩网QIDONGZHULINGKAIGUANBINGZHIYUMANSUDANGYUNZHUAN;

    Starting the command switch and placed in a slow shift;
锚机

河南福彩网SHIYONGQIANJIANCHACHACHEDAI、ZHILIANSHEBEI、DAOLIANSHEBEI、LIHEQIDENGSHIFOUZHENGQUE,MADAZHENGFANKONGZHUANSHIYANBINGQUERENZHENGCHANG。

锚机注意事项
  • 04

    河南福彩网ZHUYISHIFOUYOUYISHENGHEZHENDONG;

    Pay attention to whether there is a different sound and vibration;
  • 05

    ZHUYIJIZUDEGONGZUOQINGKUANG;

    Attention to the work unit
  • 06

    河南福彩网ZHUYIGEZHOUCHENGDEYUNZHUANQINGKUANG;

    Pay attention to the workings of each bearing;

上一产品:长途快速运梁车

下一产品:液压起锚机

我要订购: